MSDS

CHEMATRON, INC.
5216 HOVIS ROAD NOTE: N/E = Not Established
CHARLOTTE, N.C. N/D = No Data
(704) 392-4293 FAX (704) 392-4427 N/A = Not Applicable
Chemtrec; (800) 424-9300

I. IDENTIFICATION
DEGREE OF HAZARD: 0. Insignificant 1. Slight 2. Moderate 3. High 4. Extreme
HEALTH: 1 FLAMMABILITY: 0 REACTIVITY: 0

MANUFACTURERS NAME: CHEMATRON, INC.

ADDRESS: 5216 Hovis Road Charlotte NC 28208

TRADE NAME: CHEMAPRINT JPM-5000 SUPREME

SHIPPING: DOT: Not regulated

PREPARED BY: Reg Plaxton DATE PREPARED: 18/02/08

II. HAZARDOUS INGREDIENTS
MATERIAL OR COMPONENT CAS NUMBER % HAZARD DATA

None as defined by OSHA; 29 CFR 1910.1200

III. PHYSICAL DATA

BOILING POINT (F): >212º MELTING POINT: N/A

VAPOR DENSITY (AIR=1): N/D VAPOR PRESSURE: N/D

SPECIFIC GRAVITY (WATER=1): 1.00 – 1.10 SOLUBILITY IN WATER: Disperses & thickens

PERCENT VOLATILES BY VOL. BY WT.: 4.0 EVAPORATION RATE: < Ether

APPEARANCE AND ODOR: Beige liquid; mild odor

IV. FIRE AND EXPLOSION DATA

FLASH POINT (TEST METHOD): >200º F (Tag Closed Cup)

FLAMMABLE LIMITS IN AIR, % BY VOLUME: LOWER: N/D UPPER: N/D

AUTO IGNITION TEMPERATURE: N/D

EXTINGUISHING MEDIA: Carbon Dioxide, Dry Chemical, Foam or Water spray.

SPECIAL FIRE FIGHTING PROCEDURES: Keep containers cool with water spray. Wear self contained positive pressure breathing apparatus.

UNUSUAL FIRE AND EXPLOSION HAZARD: None known.

V. HEALTH HAZARD INFORMATION

TOXICITY DATA

Acute Toxicity

LD50 > 2000 mg/kg Rat

Primary Irritation

skin Nonirritant Rabbit OECD 404
eye Nonirritant Rabbit OECD 405

Adverse effects in man

Additional Information The toxicological data is based on the known properties of the components.

PRIMARY ROUTES OF EXPOSURE :

Inhalation, Skin Contact

EFFECTS OF OVEREXPOSURE

ACUTE OVEREXPOSURE

INHALATION May cause upper respiratory tract irritation.

EYE Direct contact may cause irritation, redness, tearing, blurred vision.

SKIN Direct contact may irritate skin.

INGESTION Can cause gastrointestinal irritation, nausea, vomiting, diarrhea.

CHRONIC OVEREXPOSURE N/D

EMERGENCY AND FIRST AID PROCEDURES

EYES: Flush with water for 15 minutes and get medical attention.

SKIN: Flush affected area with water. Wash with soap and water. Remove and launder clothing before reuse. Get medical attention if irritation develops.

INHALATION: Remove from exposure. Give Oxygen or artificial respiration as needed. Obtain medical attention.

INGESTION: Obtain medical attention immediately.

VI. REACTIVITY DATA

STABILITY: Stable

INCOMPATIBILITY: None Known

HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Dioxide, Carbon Monoxide

CONDITIONS CONTRIBUTING TO HAZARDOUS POLYMERIZATION: Will not occur

VII. DISPOSAL, SPILL OR LEAK PROCEDURES

ECOLOGICAL INFORMATION

ECOTOXICITY

Fish Toxicity LC50 > 100 mg/ml 96 Hour

PERSISTANCE AND DEGRADABILITY

Summary Eliminated by Biodegradation and absorption onto effluent sludge

Behavior in treatment plants

Additional Ecology Data

BOD 5 day 320 mg/L

BOD 28 day 650 mg/L

COD 630 mg/L

Tested Material Based on known data of the components

Additional Information

WASTE DISPOSAL METHOD: Disposal must be made in accordance with applicable government regulations.

PRECAUTIONS IF MATERIAL IS SPILLED OR RELEASED:

Where exposure level is not known, wear NIOSH approved positive pressure self contained respirator. Where exposure level is known, wear NIOSH approved respirator suitable for level of exposure, if needed. In addition to the protective clothing/ equipment in "Personal Protective Equipment" wear impervious boots and rain suit. Cover spills with compatible absorbent material. Transfer to suitable container for disposal or reclamation.

NEUTRALIZING CHEMICALS: N/A

VIII. SPECIAL PROTECTION INFORMATION

VENTILATION REQUIREMENTS: Provide sufficient mechanical (general) and/or local exhaust to maintain exposure below any established Threshold Limit Value

SPECIFIC PERSONAL PROTECTIVE EQUIPMENT

RESPIRATORY: Where exposure levels are below Permissible Exposure Limit (PEL), no respiratory protection is required. Where exposures exceed PEL, use respirator approved by NIOSH for the material and level of exposure. Refer to "Guide To Industrial Respiratory Protection" (NIOSH).

EYE: NIOSH/MSHA- approved safety glasses, goggles or face shield when there is possible contact.

SKIN: Impervious gloves, apron, and other necessary clothing to prevent contact.

OTHER HYGIENIC AND WORK PRACTICES: Engineering controls are usually not necessary if good hygiene practices are followed. Before eating, drinking, or smoking wash hands thoroughly with soap and water. Accessible eyewash fountain and safety shower recommended.

IX. SPECIAL PRECAUTIONS

PRECAUTIONARY STATEMENTS: Avoid repeated or excessive skin contact. Wash thoroughly after
using.

OTHER HANDLING AND STORAGE REQUIREMENTS:

Do not allow product to freeze. Keep container tightly closed when not in use. Mix well before using.

X. REGULATORY INFORMATION

All ingredients of this product are listed on the TSCA inventory.

SECTION 313 SUPPLIER NOTIFICATION

This product contains the following chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372):

CAS # CHEMICAL NAME PERCENT BY WEIGHT
NONE

This information should be included in all MSDSs that are copied and distributed for this material.

Disclaimer of Liability
The information contained in this MSDS was obtained from reliable sources. However ,the information is provided without any warranty, expressed or implied, regarding its correctness. Recipients are advised to confirm in advance that the information is current and applicable to their situation. Since conditions of use are beyond Chematron, Inc control, we do not assume responsibility and expressly disclaim liability for loss, damage, or expense arising out of or connected with the handling, storage, use or disposal of the product.
The information accumulated for this MSDS is to be used only for this product. If this product is used as a component in another product, this MSDS information may not be applicable.